Car Checks(PVT)Ltd.
  55/1 Sunethradevi Road,
  Kohuwala,
  Sri Lanka.
  Phone : 2819333,2819335
  Hotline: 0728353535
  Fax:2819334
  E-mail : appointment@carchecksonline.com

85.36
100

VEHICLE INSPECTION SHEET - 1 of 5
Messrs :       Deenaka
This report is confidential and for guidance of address only. And is not to be used for any other purpose or distribute to any other party or be published in any form. Inspection is necessarily superficial and no dismantling nor reassembling of any mechanism implied nor accepted.
   
Time of Inspection 12/07/2018 12:19 PM Place of Inspection Car Checks
Primary vehicle details:
Registration No WP GK-4358 Year of Manufacture 2001
Country of Origin Japan Vehicle Make Mitsubishi
Model Montero Chassis Number JMYLYV78W2J000500
Fuel Type Diesel
Engine model Body Colour (Repainted) Red/Grey
Engine Replaced No Odometer Reading 226384 km
No of seats 07
Roof Standard Wheel Condition Serviceable
Windscreen cracked No Alterations No
Accidents No Air Conditioning Good
Interior:
Interior Type Leather Interior Condition Dirty
Interior Plastics Bad Power Steering Good
Electric Seats Good Seat Belts Good
Air Bags Good Number of Air Bags 4
Standard Mirrors None Power Mirrors Bad
Fold Mirrors Good Central Lock Good
Power Shutters Bad Sun Roof Bad
Interior Lights Not Functioning Meters Functioning
Self Starter Good Horn Good
Reverse Sensor None Reverse Camera None
Climate Control Good Automatic Door None
Dual A/C Good
Comments Driver seat bolster damaged
Additional carpet fitted
Sunroof not functioning
Recommend servicing AC
Recommend inspection of cabin filter
Driver side AC vent broken		 Comments Recommend dealer inspection of fault codes, see attached sheet
Center armrest latch broken
Rear left power shutter wont operate from driver switch
Power mirrors wont adjust to left and right sides
Driver side vanity mirror light not functioning
Rear AC vents broken
Recommend servicing power shutters
  Car Checks(PVT)Ltd.
  55/1 Sunethradevi Road,
  Kohuwala,
  Sri Lanka.
  Phone : 2819333,2819335
  Hotline: 0728353535
  Fax:2819334
  E-mail : appointment@carchecksonline.com
VEHICLE INSPECTION SHEET - 2 of 5
Type of Vehicle Jeep
Driving System FF
Number of Doors 5
Roof Standard
Wheel Type Alloy
Tyre wear(%) Front: Left:100 Right:90
Rear: Left: 100 Right:90
Comments Recommend replacing tires
Recommend wheel alignment
Mechanical 53.36% out of 60.00%
Engine 7.714% out of 8.571%
Suspension 8.571% out of 8.571%
Steering 5.143% out of 8.571%
Brakes 6.531% out of 8.571%
Transmission 8.254% out of 8.571%
Cooling 8.571% out of 8.571%
Exhaust 8.571% out of 8.571%
85.36% out of 100%
Body/Chassis 25.00% out of 25.00%
Pillars 12.50%out of 12.50%
Box-Joints 12.50% out of 12.50%
Exterior 7.00% out of 10.00%
Exterior 7.00% out of 10.00%
Tyre wear 0.00% out of 5.00%
Tyre wear 0.00% out of 5.00%
Exterior .....
Headlights Bad
Signal Lights Good
Hazard Warning Lights Good
Brake Lights Good
Park Lights Good
Reverse Lights Good
Fog Lights Good
Windscreen Wipers Bad
Windscreen Wiper Mechanism Good
Windscreen Wiper Nozzles Bad
Comments Head light washers not functioning
Head lamp HID beam intensities mismatched
Recommend replacing wiper blades
Rear washer not functioning
Front washers not functioning correctly
Body .....
A-Pillar Good
B-Pillar Good
C-Pillar Good
D-Pillar Good
Comments Front bonnet removed and refitted
Subframe
1-BoxJoint Good
2-BoxJoint Good
3-BoxJoint Good
Comments Nothing to add.
  Car Checks(PVT)Ltd.
  55/1 Sunethradevi Road,
  Kohuwala,
  Sri Lanka.
  Phone : 2819333,2819335
  Hotline: 0728353535
  Fax:2819334
  E-mail : appointment@carchecksonline.com
VEHICLE INSPECTION SHEET - 3 of 5
Braking System
ABS Good
Hand Brake Good
Brake Fluid Bad
Master Pump Good
Brake Servo Good
Front Brake Hoses Good
Front Brake Discs Bad
Front Brake Pads Bad
Front Brake Drums None
Front Brake Shoes None
Rear Brake Hoses Good
Rear Brake Discs Bad
Rear Brake Pads Bad
Rear Brake Drums None
Rear Brake Shoes None
Brake Padal Rubber Good
Brake Light Switch None
Brake Oil Reservoir Good
Front Brake Caliper Pins Good
Rear Brake Caliper Pins Good
Front Brake Caliper Washers Good
Rear Brake Caliper Washers Good
Front Brake Caliper Pistons Good
Rear Brake Caliper Pistons Good
Front Brake Binding No
Rear Brake Binding No
Comments Recommend replacing brake fluid
Rear brake pads worn
Front brake pads 80% worn
Front and rear brake discs worn
Engine
Accelerator Pedal Rubber Good
Hybrid System None
Turbo Good
Super Charger None
Throttle Body Good
High tension leads Good
Tappet Cover Good
Tappets Good
Head Gasket Good
Misfiring No
Cylinder Compression Good
Distributor None
Igniter Coils None
Alternator Good
Alternator belt Bad
Timing Chain Good
Timing Belt None
Engine Mounts Good
Sump Gasket Good
Push Rods None
Air Filter Bad
Air Flow Sensor Good
Induction Housing Good
Camshaft Sensor Good
Camshaft Oil Seal Good
Crankshaft Sensor Good
Crankshaft Oil Seal Good
Burning Oil No
Comments Fuel leak detected on top left side of engine, recommend further inspection
Crank oil seal leaking flywheel and pulley side
Recommend replacing drive belts
Recommend servicing engine
Recommend replacing air filter
Steering .....
Steering Box None
Steering Rack Good
Steering Rack-end Bad
Tie Rod Bad
Lower Ball Joints Good
Upper Ball Joints Good
Comments Rack ends and tie rod ends worn
Cooling System .....
Water Pump Good
Coolant Lines Good
Radiator Good
Radiator Fan Good
Thermostat Good
Radiator Cap Good
Top Tank Good
Bottom Tank Good
Core Good
Comments Recommend coolant flush
  Car Checks(PVT)Ltd.
  55/1 Sunethradevi Road,
  Kohuwala,
  Sri Lanka.
  Phone : 2819333,2819335
  Hotline: 0728353535
  Fax:2819334
  E-mail : appointment@carchecksonline.com
VEHICLE INSPECTION SHEET - 4 of 5
Transmission .....
Gearbox Good
Gear Selection Good
Gearbox Mounts Bad
Shafting None
Gearbox Shaft(s) Good
Gearbox Cable(s) Good
Gearbox Rasors Good
Gear Engagement Good
Gearbox Oil Good
Continuous Velocity Transmission System None
Clutch None
Clutch Plate None
Clutch Pedal Rubber None
Pressure Plate None
Release Bearing None
Clutch Pump None
Clutch Cables None
Clutch Pump Fluid None
Clutch Servo None
Front inner CV Joints Good
Front outer CV Joints Good
Front Differential Good
Front Propeller Shaft Good
Front Universal Joints Good
Rear inner CV Joints Good
Rear outer CV Joints Good
Rear Differential Good
Rear Propeller Shaft Good
Rear Propeller Shaft Universal Joints Good
Front Drive-shafts Good
Front Drive-shaft Oil Seals Good
Rear Drive-shafts Good
Rear Drive-shaft Oil Seals Good
Traction Control Good
Active Stability Control Good
Triptronic System Good
Economy Mode Good
Sport Mode Good
Comments Front differential mount weak and cracking
Gearbox mount weak
Exhaust system .....
Exhaust manifold Good
Connecting Pipe Good
Front Pipe Good
Middle Silencer (Resonator) Good
Catalytic Converter Good
Extension Pipes Good
Flanges Good
Gasket Good
Hangers Good
Clamps Good
Comments Nothing to add.
Suspension .....
Front Swing Arms Good
Front Upper Swing-Arm Bushes Good
Front Lower Swing-Arm Bushes Good
Front Shocks Good
Front Shock Mounts Good
Front Shock Bushes Good
Front Electronic Damping None
Front Coil Springs Good
Front Coil Spring Damping Good
Front Shock Bumpers Good
Front Lower Forward Torsion Bar Good
Front Lower Forward Torsion Bar Bushes Good
Front Lower Aft Torsion Bar Good
Front Lower Aft Torsion Bar Bushes Good
Front Upper Forward Torsion Bar Good
Front Upper Forward Torsion Bar Bushes Good
Front Upper Aft Torsion Bar Good
Front Upper Aft Torsion Bar Bushes Good
Front Stabilizer Bar Multi-links Good
Front Strut Brace(s) None
Rear Swing Arms Good
Rear Upper Swing-Arm Bushes Good
Rear Lower Swing Arm Bushes Good
Rear Shocks Good
Rear Shock Mounts Good
Rear Shock Bushes Good
Rear Leaf Springs None
Rear Leaf Spring Bushes None
Rear Electronic Damping None
Rear Coil Springs Good
Rear Coil Spring Damping Good
Rear Shock Bumpers Good
Rear Lower Forward Torsion Bar Good
Rear Lower Forward Torsion Bar Bushes Good
Rear Lower Aft Torsion Bar Good
Rear Lower Aft Torsion Bar Bushes Good
Rear Upper Forward Torsion Bar Good
Rear Upper Forward Torsion Bar Bushes Good
Rear Upper Aft Torsion Bar Good
Rear Upper Aft Torsion Bar Bushes Good
Rear Stabilizer Bar Multi-links Good
Rear Strut Brace(s) None
Comments Recommend dismantle and inspection of all shock absorbers
  Car Checks(PVT)Ltd.
  55/1 Sunethradevi Road,
  Kohuwala,
  Sri Lanka.
  Phone : 2819333,2819335
  Hotline: 0728353535
  Fax:2819334
  E-mail : appointment@carchecksonline.com
VEHICLE INSPECTION SHEET - 5 of 5
Referance Diagram
EXPLANATION OF MARKING

A : Scratch           G : Hole
B : Bend              H : Replaced
C : Corrode          I : Painted
D : Dent
E : Tear
F : Wave
SIZE OF DENT AND SCRATCH

1 : Slight             4 : Large
2 : Small             5 : Heavy
3 : Medium         



REMARKS: This report is governed by, and for your exclusive use. Unless specifically agreed, the relates to the facts as recorded by us within the limits of instructions received and, if appropriate, states it’s opinion based on such facts. In providing our services, we do not take the place of designers, manufactures, producers, operators, transporters, sellers, buyers or owners, who, notwithstanding our actions, are not released from any of their obligations of whatever nature. In particular, our inspection and the resulting report do not release the seller of goods from it’s own obligations toward the buyer of such goods. Any information and recommendations supplied by us shall not be held or construed to amount to approval or acceptance of the items in connection with which the information and recommendations supplied or of their of the quality, merchantability or fitness for any purpose. The above results are valid at the time and place of inspection.